FULLER H B CO -- SC-0840 ADHESIVE  -- 8040-00-754-2685
<pre>=====================  Product Identification  =====================

Product ID:SC-0840 ADHESIVE
MSDS Date:03/13/1992
FSC:8040
NIIN:00-754-2685
=== Responsible Party ===
Company Name:FULLER H B CO
Address:1200 WOLTERS BLVD
City:VADNAIS HEIGHTS
State:MN
ZIP:55110
Country:US
Info Phone Num:612-481-3300
Emergency Phone Num:612-481-3300
CAGE:0DH19
=== Contractor Identification ===
Company Name:H.B. FULLER COMPANY
Address:3500 LEXINGTON AVENUE N.
Box:City:ST. PAUL
State:MN
ZIP:55126-8076
Country:US
Phone:612-236-5300/ -5309 FAX
CAGE:0DH19

=============  Composition/Information on Ingredients  =============

Ingred Name:CYCLOHEXANONE  (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 1-10% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 25 PPM
ACGIH TLV:S, 25 PPM; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:FORMALDEHYDE  (SARA III)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 0.19% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM; A2; 9394
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS

Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK)  (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300STEL;9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:TOLUENE  (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:ACETONE  (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 10% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL;9294
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:NO
Reports of Carcinogenicity:NTP:YES    IARC:YES	  OSHA:YES
Health Hazards Acute and Chronic:MAY CAUSE MODERATE EYE IRRITATION.
    LIQUID CONTACT WILL DRY AND DEFAT THE SKIN. PROLONGED CONTACT MAY
    CAUSE DERMATITIS. VAPORS MAY IRRITATE THE NOSE, THROAT AND
    RESPIRATORY TRACT AND CAUSE HEADACHES, N AUSEA OR UNCONSCIOUSNESS.
    LONG-TERM OVEREXPOSURE MAY CAUSE LIVER AND KIDNEY DAMAGE.
Explanation of Carcinogenicity:CONTAINS F	     [50-00-0] WHICH IS
    LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, DERMATITIS,
    UPPER RESPIRATORY TRACT IRRITATION, NAUSEA, VOMITING, DIARRHEA,
    LIVER/KIDNEY DAMAGE, UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

=======================  First Aid Measures  =======================

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
    OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
    WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
    ATTENTION. IN HALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
    MEDICAL ATTENTION. INGESTION: GET MEDICAL ATTENTION IMMEDIATELY.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:0F,-18C
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE, FOAM
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
    FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
    SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:THERE IS THE POSSIBILITY OF PRESSURE
    BUILDUP IN CLOSED CONTAINERS WHEN HEATED.

==================  Accidental Release Measures  ==================

Spill Release Procedures:CONTAIN AND REMOVE WITH INERT ABSORBENT. USE
    NON-SPARKING TOOLS. KEEP SPILL OUT OF SEWERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND FLAME.
    AVOID BREATHING VAPORS. USE ONLY WITH ADEQUATE VENTILATION. AVOID
    CONTACT WITH EYES, SKIN AND CLOTHING.
Other Precautions:KEEP CONTAINER CLOSED. EMPTIED CONTAINERS RETAIN
    VAPOR AND PRODUCT RESIDUE. OBSERVE ALL LABELED SAFEGUARDS UNTIL
    CONTAINER IS CLEANED. DO NOT CUT OR WELD ON OR NEAR THIS CONTAINER.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
    EXOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS PER
    CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND NIOSH RESPIRATOR
    SELECTION.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION TO
    MAINTAIN EXPOSURE LEVELS.
Protective Gloves:RUBBER
Eye Protection:SAFETY GLASSES OR GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO AVOID
    SKIN CONTACT. AN EMERGENCY EYE WASH STATION AND SHOWER SHOULD BE
    AVAILABLE.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
    AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
OVEREXPOSURE TO TOLUENE MAY CAUSE FEMALE AND MALE REPRODUCTIVE
    DISORDERS, BASED ON TESTS WITH LABORATORY ANIMALS.

==================  Physical/Chemical Properties  ==================

HCC:F2
Boiling Pt:B.P. Text:>133F,>56C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:< 1
Evaporation Rate &amp; Reference:NOT GIVEN
Solubility in Water:NON-MISCIBLE
Appearance and Odor:LIQUID
Percent Volatiles by Volume:70 %

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HEAT, OPEN FLAME
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
    UNIDENTIFIED ORGANIC COMPOUNDS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
    ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
    LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.